清洗机网
通过式清洗机
通过式清洗机
通过式清洗机
往复式清洗机
悬挂链通过式清洗机
活塞杆清洗机
活塞杆清洗机
缸筒清洗机
缸筒清洗机
长缸筒清洗机
缸筒组合式清洗机
单工位清洗机
缸体翻转清洗机
人才招聘_Jobs
优秀的人才团队永远是构筑百年企业的基石,是推动企业持续发展的动力,是企业引领运动潮流的源泉。
您对我们充满梦想,我们对您充满期待......
在线订单_Order
欢迎你选购我们公司的产品!
请您将所需的产品情况填入下面的表格,我们将制定有效的可行性方案给您,我们收到你的订单后会在最短的时间内响应。
行业动态_News
清洗机>>行业动态
碳氢清洗剂的优点
发布者:xiaoyi555  日期:2016-05-11  点击:3731

碳氢清洗剂是馏程在140-190℃左右的正构和异构烷烃。一般是石油经粗蒸馏、加氢、精馏、异构化制成。碳氢清洗剂与其他清洗机清洗剂相比有许多优势:

Hydrocarboncleaning agent is in range 140-190 degrees Celsius metklestified and isoalkane.The crude oil is prepared by crude distillation, hydrogenation, distillationand isomerization. Hydrocarbon cleaning agent has many advantages compared withother cleaning machine(www.qingxijiw.com)  agents:

1、清洗性能好。碳氢清洗剂与大多数的润滑油、防锈油、机加工油同为非极性的石油馏分,根据相似相容的原理,碳氢清洗剂清洗这些矿物油的的效果要好于卤代烃和水基清洗剂。

1,good cleaning performance. Hydrocarbon cleaning agent and most of thelubricating oil, anti rust oil, machine oil processing with non polar fractionsof petroleum, according to the principle of compatible and hydrocarbon cleaningagent cleaning these mineral oil is better in halogenated hydrocarbons andwater-based cleaning agent.

2、无毒。经毒理试验,碳氢清洗剂的吸入毒性、经口毒性和皮肤接触毒性均为低毒, 且不属于致癌物质,与卤代烃相比对清洗操作人员更安全。

2,non-toxic. The toxicological test, hydrocarbon cleaning agent inhalationtoxicity, oral toxicity and skin contact toxicity is low and does not belong tothe carcinogenic substances, on the cleaning operation personnel is more securethan with alkyl halides.

3、材料相容性好。碳氢清洗剂中不含水份和氯、硫等腐蚀物,对各种金属材料不会产生腐蚀和氧化。另外,由于其属于非极性溶剂,对大部分塑料和橡胶没有溶解、溶胀和脆化作用,因此应用范围极广。

3,good compatibility of materials. Hydrocarbon cleaning agent does not containwater and chlorine, sulfur and other corrosive substances, for all kinds ofmetal materials will not produce corrosion and oxidation. In addition, becauseof the non polar solvent, the majority of plastic and rubber are not dissolved,swollen and brittle, so the application range is very wide.

4、可彻底挥发无残迹。碳氢清洗剂是非常纯净的精制溶剂,在常温和加温状态下均可完全挥发,没有任何残留。

4,can be completely free of volatile remnants. Hydrocarbon cleaning agent is avery pure refined solvent, in the normal temperature and under the state ofheating can be completely volatile, without any residue.

5、不破坏环境。碳氢清洗剂可以自然降解,清洗废液可以放入燃煤或燃油锅炉中焚烧, 焚烧的生成物主要为CO2和水,对空气没有污染。碳氢清洗剂中不含氯,对臭氧的 破坏系数为零。

5,do not damage the environment. Hydrocarbon cleaning agent can be naturally degraded,cleaning waste liquid can be put into the burning of coal or oil fired boiler,and the burning of the product is mainly CO2 and water, no pollution to theair. Hydrocarbon cleaning agent does not contain chlorine, ozone destructioncoefficient is zero.

6、价格便宜。普通碳氢清洗剂的价格相当于F-113价格的50%以下,是某些ODS替代品价格的二十分之一。由于碳氢清洗剂的密度为0.75左右,大大低于卤代烃溶剂的密度,因此在同样容积的清洗槽中碳氢清洗剂的加入量仅为卤代烃清洗剂的一半。

6,the price is cheap. The price of a common hydrocarbon cleaning agent isequivalent to less than 50% of the F-113 price and is the price of some of the1/20 ODS alternatives. Due to the hydrocarbon cleaning agent density is about0.75, significantly lower than the density of halogenated hydrocarbon solvent,so in the same volume of cleaning tank of hydrocarbon cleaning agent amount isonly half of the halogenated hydrocarbon cleaning agent.

7、蒸发损失小。碳氢清洗剂沸点一般在150℃以上,在使用保管过程中挥发损失要比沸点在40~80℃的卤代烃小得多,对包装物和清洗机设备的密封要求很低。

7,the evaporation loss is small. Hydrocarbon cleaning agent boiling pointgenerally in more than 150 DEG C, in use and safekeeping of the volatile lossthan the boiling point of the halocarbons 40-80 DEG C is much smaller, on thepackaging and equipment sealing requirements is very low.

 
[返回] [打印]
Copyright © www.qingxijiw.com 清洗机网 All reserved. 公司地址:江苏无锡惠山区西漳工业园漳兴路1-5号 联系人:王经理 销售热线:13812298052 电话:0510-83508107

清洗机网专业生产销售清洗设备、清洗机、涂装设备、自动通过式清洗机、悬挂输送式清洗机、超声波清洗机、烘干机、生产装配线等设备的专业厂家,价格实惠,欢迎咨询!

友链: 技术支持:速联科技